Volvo Penta DPI-A Steering System Ground Cable | 23329808

Part Number: 23329808
Brand: Volvo Penta
Official Product Type: Ground Cable Steering System Electrical

The Volvo Penta 23329808 is a genuine OEM ground cable specified for the DPI-A steering system assembly. It provides the grounding connection within the steering-system electrical layout and is listed at diagram position 19 in the DPI-A steering schematic, alongside the steering cylinder, hydraulic manifold, hose assemblies, and a companion ground cable in the same circuit.

Compatible Applications

• Volvo Penta DPI-A Steering System assembly (confirmed schematic reference, diagram position 19)
• Additional DPI variants may apply verify against your drive serial number and the correct Volvo Penta steering diagram before ordering

Serial Number & Fitment Notice

Fitment can vary by drive package, steering-system layout, and serial-number range. Always confirm part number 23329808 against your exact engine or drive serial number and the applicable DPI-A steering diagram before ordering particularly on installations that have had prior steering, hose, or harness service.

System & Diagram Position

System: Steering Electrical Grounding
Diagram Position: Object 19 (DPI-A Steering System schematic)

Engine Family

DPI-A drive package. Confirm applicability to your specific drive serial number via the Volvo Penta parts diagram.

When to Replace

• Visible corrosion, broken strands, or damaged insulation on the existing cable
• Overheated or loose terminals
• Intermittent grounding symptoms or unexplained electrical faults in the steering circuit
• Any time the surrounding steering assembly is being serviced and the cable has been disturbed or shows age-related wear

Service Interval

Inspect at every steering-system service. Ground cables do not have a fixed replacement interval but should be replaced immediately if corrosion, damage, or resistance issues are found. Proactive replacement during a full steering overhaul is recommended.

Installation Notes

• Confirm the correct diagram position and serial-number fitment before installation
• A companion ground cable (23329811) is listed in the same DPI-A steering assembly confirm which position each cable occupies before ordering
• Clean all grounding surfaces and inspect terminal contact points before fitting the replacement cable
• A reliable low-resistance ground connection depends on both the correct cable and a clean, undamaged mounting surface

Part Number & Supersession

OEM Part Number: 23329808
Supersedes: No confirmed supersession on record at time of listing
Replaced By: No confirmed replacement number on record verify current status with Volvo Penta parts if ordering for a critical application

Dimensions & Weight

Approximate weight: 0.03 kg (0.07 lb). Cable length and terminal configuration match the DPI-A steering schematic specification confirm fitment via diagram before ordering.

Kit Contents

Single ground cable (23329808). No additional hardware included.

Related Parts

• Companion ground cable: 23329811 (also listed in DPI-A steering assembly)
• Steering cylinder: 22452005
• Hydraulic manifold: 23259070
• Hose assembly: 23258506
• Hose assembly: 23293608

Parts Desk Insights

Best use case: Steering-system overhaul or any time the DPI-A steering assembly is being fully serviced. Replacing the ground cable at the same time as hoses and the manifold is low-cost insurance against a return visit for an electrical fault.

Common customer issue: Ground cables are easy to overlook because they can look fine externally while still causing intermittent or hard-to-trace electrical problems. The DPI-A assembly includes two ground cables in close proximity confirm diagram position 19 vs. the companion cable position before ordering to make sure you have the right one.

Technical FAQ

Q: What is the difference between 23329808 and 23329811?
A: Both are ground cables listed in the same DPI-A steering assembly. They occupy different diagram positions. Confirm which position applies to your specific repair using the Volvo Penta steering schematic.

Q: Can I substitute a generic ground cable of the same length?
A: Volvo Penta specifies OEM cables for steering-system grounding. Terminal configuration, wire gauge, and insulation rating are all application-specific substitution is not recommended for a safety-critical steering circuit.

Q: How do I know if my ground cable is causing an electrical fault?
A: Use a multimeter to check resistance across the cable and at the terminal connections. Elevated resistance or an open circuit confirms replacement is needed. Intermittent steering electrical faults with no other obvious cause are also a strong indicator.